Vehicle Data Hub

2004 Chevrolet Cavalier engine problems

22 complaints about engine have been filed for the 2004 Chevrolet Cavalier, which is 5% of all its NHTSA complaints.

At a glance

Complaints
22 5% of this year's complaints
Typical mileage
51,000 miles 18 complaints with mileage
Crashes and fires
1 and 1
Injuries and deaths
1 and 0

Source: NHTSA owner complaints

When engine problems show up

Engine complaints by mileage, 2004 Chevrolet Cavalier Complaints by odometer reading in 20,000-mile steps. The median is about 51,000 miles. 0k to 20k miles: 5 complaints 20k to 40k miles: 3 complaints 40k to 60k miles: 2 complaints 60k to 80k miles: 2 complaints 80k to 100k miles: 2 complaints 100k to 120k miles: 2 complaints 120k to 140k miles: 1 complaints 140k to 160k miles: 1 complaints 160k to 180k miles: 0 complaints 180k to 200k miles: 0 complaints 200k+ miles: 0 complaints 040k80k120k160k200k miles Typical: 51,000 miles
Based on 18 complaints that include mileage. 56% were reported before 60,000 miles. The amber marker shows the median: half of these complaints happened before that mileage.
View the numbers
MileageComplaints
0k to 20k miles5
20k to 40k miles3
40k to 60k miles2
60k to 80k miles2
80k to 100k miles2
100k to 120k miles2
120k to 140k miles1
140k to 160k miles1
160k to 180k miles0
180k to 200k miles0
200k+ miles0

What the data shows

Of the 18 engine complaints that report mileage, the median is about 50,000 miles, and 56% were reported before 60,000 miles.

These complaints mention 1 crash, 1 fire, 1 injury.

What owners wrote

Dt: while driving the contact's vehicle was involved in an accident due to a possible medical condition. The vehicle caught on fire immediately upon impact. The vehicle was deemed a total loss from the insurance company. A representative from the manufacturer inspected the vehicle and was unable to determine the cause of the fire due to the extensive damage. The solid fuel lines were intact as well as the gasoline tank. Updated 02/26/06.

Reported at 30,300 miles, October 2005 CrashFireInjury

2004 cavalier, 2.2l dohc, 5-speed manual transmission. While driving at 60 MPH vehicle felt as if cruise control was engaged. Rpms would not fall off as fast as usual when foot taken off gas, and when I depressed the clutch (which was just replaced last week due to another known issue that chevy refuses to recall) rpms went above 4,000. Tapped gas pedal thinking maybe it was stuck and it only revved higher and did not come down on its own.

Reported at 152,000 miles, May 2014

Other problems reported for the 2004 Chevrolet Cavalier

Engine problems in other years

Engine problems across all Chevrolet models