2002 GMC Envoy recalls
The 2002 GMC Envoy is affected by 13 safety recall campaigns in NHTSA's records.
At a glance
- Recall campaigns
- 13
- Most recent
- June 23, 2004
Source: NHTSA recall records
Recall campaigns
| Campaign | Reported | Part | Problem | Vehicles |
|---|---|---|---|---|
| 04V-289 | June 23, 2004 | Engine and engine cooling | Some sport utility vehicles equipped with an electronically controlled air suspension (ecas) have a condition in which the ecas may produce a brief electrical spike while the vehicle is operating. This electrical spike can disrupt the powertrain control module (PCM) causing the vehicle to stall. | 29,951 |
| 04V-201 | April 28, 2004 | Seat belts | Certain light duty pickup trucks and sport utility vehicles fail to conform to federal motor vehicle safety standard no. 209, "seat belt assemblies." one of the two sensors in the driver's and front passenger's seat belt retractors could be inoperative. The seat belt retractors will lock when the belt webbing is… | 261,801 |
| 04V-046 | February 4, 2004 | Visibility (windshield wiper/washer) | Certain sport utility vehicles have windshield wiper systems that will not turn on, cease operation while in use, fail to turn off/on by themselves (moisture sensitive wiper system), or have continuous windshield washer pump operation because the presence of water within the wiper modules can either cause a short… | 581,394 |
| 03V-250 | July 15, 2003 | Equipment (other, owners/service/other manual) | Certain minivans, passenger and sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage system." the owner's manual does not explain the meaning of the location symbols for the child restraint lower universal anchorage system. | 1,707,825 |
| 03V-096 | March 19, 2003 | Electrical system (wiring, interior/under dash) | Certain sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standards no. 101, "control location, identification, and illumination" and no. 208, "occupant crash protection." these vehicles have an intermittent condition during vehicle start-up in which the instrument panel… | 314,300 |
| 03V-075 | March 6, 2003 | Power train (automatic transmission) | Certain sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 114, "theft protection." these vehicles are equipped with a mechanical override that could allow the ignition key to be removed with the shift lever in a position other than park. In addition, these… | 511,167 |
| 02V-273 | October 4, 2002 | Structure (body) | Certain sport utility vehicles are missing welds on the rear floor plan. | 46 |
| 02V-121 | August 23, 2002 | Fuel system, gasoline (delivery, hoses, lines/piping, and fittings) | On certain sport utility vehicles, a fuel filter fitting can become disconnected. If this were to occur while attempting to start the engine, a no-start condition would result and fuel would be pumped out the fuel filter onto the ground. | 136,511 |
| 02V-222 | August 9, 2002 | Air bags (frontal) | Certain passenger, mini vans, and sport utility vehicles have an air bag inflator on the driver's side that could fracture at a weld during a deployment. | 133,221 |
| 01V-334 | October 17, 2001 | Power train (transfer case (4-wheel drive)) | Vehicle description: sport utility vehicles equipped with 4-wheel drive. The calibration of the transfer case control module could cause insufficient high speed gear engagement. | 78,004 |
| 01V-283 | September 5, 2001 | Power train (transfer case (4-wheel drive)) | Vehicle description: sport utility vehicles (4 wheel-drive). Some of these vehicles were built with a range shift collar in the transmission transfer case that contains cracks. | 895 |
| 01V-158 | May 16, 2001 | Structure (body) | Vehicle description: certain sport utility vehicles fail to comply with requirements of fmvss no. 201, "occupant protection in interior impacts." these vehicles have a console cover/armrest lid latch that could release at less than the 10g vertical load requirement of the standard. | 8,197 |
| 01V-126 | April 12, 2001 | Suspension (front, control arm, lower arm) | Vehicle description: sport utility vehicles. Under certain circumstances the front lower control arm brackets may fracture. This fracture could result in separation of the front lower control arm from the frame. | 30,476 |