2022 Chevrolet Bolt EV problems
NHTSA has received 94 complaints about the 2022 Chevrolet Bolt EV, and 31% of them involve electrical system. After that come fuel system (12%) and drivetrain & axles (11%).
At a glance
- Complaints
- 94 filed with NHTSA
- Most reported
- Electrical system 31% of complaints
- Crashes and fires
- 5 and 0
- Injuries and deaths
- 0 and 0
- Typical mileage
- 7,000 miles 12 complaints with mileage
Source: NHTSA owner complaints
Where the complaints are
Share of this model year's complaints by the part of the car involved. One complaint can name more than one part, so the shares can add up to more than 100%.
When problems show up
View the numbers
| Mileage | Complaints |
|---|---|
| 0k to 20k miles | 10 |
| 20k to 40k miles | 1 |
| 40k to 60k miles | 0 |
| 60k to 80k miles | 1 |
| 80k to 100k miles | 0 |
| 100k to 120k miles | 0 |
| 120k to 140k miles | 0 |
| 140k to 160k miles | 0 |
| 160k to 180k miles | 0 |
| 180k to 200k miles | 0 |
| 200k+ miles | 0 |
What the data shows
Among the 12 complaints that report mileage, the typical (median) problem appeared at about 7,000 miles.
Safety-related details: 5 complaints mention a crash. Its complaints are less severe on average than those of 88% of model years in our database.
Looking only at complaints filed within five years of the model year (so older and newer years are comparable), the 2022 ranks 6th most-complained-about out of 7 model years of the Chevrolet Bolt EV with enough data (94 complaints in that window). It is also covered by 7 safety recall campaigns.
What owners wrote
A few complaints as filed, shortened and with personal details removed. The first ones are among the most serious reports for this model year; the rest are typical.
The contact owns a 2022 Chevrolet Bolt EV. The contact stated that while in the process of parking the vehicle on the side of a street, the vehicle unintendedly accelerated, and the front end of the vehicle crashed into an unoccupied parked vehicle, which crashed into a second occupied vehicle parked in front of it. No property damage was reported. The vehicle came to a stop upon impact. The air bags did not deploy. The vehicle did not need to be towed. No warning lights were illuminated.
I was was traveling at 68 mph, then rear ended and pushed into the center divide. The entire front drivers tire + assembly was destroyed. The airbags didn't deploy. The cab did fill with a white 'smoke'. A little bit later I received a message from the Chevy app that there was a problem with my airbags and I should seek service. My insurance has deemed the car a total loss and picked up the car and taken it to their lot for inspection.
While driving at a low speed (approx. 5–10 mph), the front passenger-side lower ball joint suffered a catastrophic structural shear without warning. This caused the wheel assembly to collapse outward and the CV axle to pull out of the transmission. The failure caused a complete loss of steering control, veering the vehicle into a curb. Physical evidence (outward axle pull and high-side rim scratches) indicates the mechanical failure preceded the impact.
The contact owns a 2022 Chevrolet Bolt EV. The contact stated that while his wife was driving 70 MPH, the vehicle inadvertently decelerated to 30 MPH with the transmission warning light and three other unknown warning lights illuminated. The failure nearly caused a collision. The vehicle was towed to the dealer; however, the dealer was unable to duplicate the failure. The dealer determined that the negative battery terminal cable was faulty and replaced the negative battery terminal cable.
The contact owns a 2022 Chevrolet Bolt EV. The contact stated while pulling out of a parking lot, the vehicle stalled, failed to shift into gear and would not turn off. A towing agent disconnected the battery and the vehicle turned off. The vehicle was then towed to the dealer where it was diagnosed that the service disconnect fuse had blown. The vehicle was repaired; however, the failure reoccurred while driving.